SUREBOND RESTAURANT AND COMMISSARY GALLERY
SUREBOND PROVIDES FLOOR AND COVE SOLUTIONS THAT SHOULD HAVE A LIFE-CYCLE OF 30+YEARS , WITH minimal MAINTENANCE for abuse.
surebond can change your bOH floors from a bleeding expense to aN appreciated capital investment
A typical "anti slip" tile in a restaurant. Add water to grease on the tile, and it becomes slippery. Grout maintenance in a fast food restaurant can happen every 7 to 10 years, according to one of our major clients. The grout starts out gray and change to black due to grease accumulation. What is worse, when the grout fails, water goes UNDER the tile and creates a hygiene problem. Eventually, the tile fails.
Rubber mats are used to stop slip and falls on wet tiles. They are also used for people standing in one spot But, rubber gets slippery when wet. Grease tracked from the fry line to the dish pit makes the mat and the surrounding floor slippery. Then, how often is the mat lifted and cleaned underneath? This allows for that area under the mat to become unhygienic.
Can everyone see the trip hazard? SLIPS now becomes TRIPS. The floor mat that was supposed to eliminate slips, can actually create a trip hazard on its own. Level surfaces with no transitions enhances employee safety.
Grout failure everywhere. You can see the different colours of grout. The dark grout is dark because of accumulation of grease. The yellow grout is likely the re-grouted area, done in the middle of the night...again. A pin hole in the grout causes water to get underneath a tile. More organic materials (grease) and fat go into the grout. Washing the floor carries more dirty water INTO the grout.
Staff washroom areas should not be over-looked, as they need to be sanitary. Easy clean up of urine and toilet overflows is essential. Employees will clean a floor if it is easy to clean.
A SureBond floor using SILIKAL® R61 CQ resin eliminates tile / grout, sheet vinyl joint failure, and difficulty in cleaning issues.
Very attractive, non slip, non porous floor. Staff will prefer employment in an environment that is safer. Also, they will be more likely to clean a floor that is easy to clean.
The floor can handle impacts. It can be repaired in 30 minutes to an 1 hour, with one hours of no water / walking on the floor. After that, the floor is ready for full-use.
Our coving can bond to concrete, wall board, and even stainless steel cabinet bases!
Our cove radius can be a short radius (2.5 cm) or long radius (5 cm). The cove - floor joint never fails. No peeling from the stainless steel cabinet either.
We travel anywhere to do our quality installations. We are a mobile operation that is based in Calgary. We have a team of road warriors that deliver on every project with a quality implementation.
Our floors can come any colour blend that the client desires. We often install reverse colour schemes of the cove, so that the cove is darker than the floor. It creates a picture frame effect.
We never get peeliing around the drains or grease traps. There are about 30 in every one of the restaurants that we do work for multi national chain.
The floors are durable for abuse from the receiving area. It can handle drops from carts entering / leaving.
We can install these floors as renovations as well. It is preferential to remove all brick tiles first. However, we can overlay over tiles that still have integrity.